How to remove and install the Rack and Pinion steering gear on Ford Ranger?

To pull out the rack and pinion assembly, the front wheels turned straight ahead and the vehicle supported adequately by jackstands. Connect the cable or jumper wire to the negative terminal of the battery, then return the steering wheel to its straight ahead position, without locking the steering column unless for 2011 models the column should be locked. The hose connections to the power steering fluid cooler for V6 2WD are to be removed, fluid drained into a suitable receptacle and the cooler removed. For 4WD models depending on variants, there are screws and retaining pins; therefore, at the side, the air deflector screws should be unscrewed and the air deflector clips must be unlocked. Detach the tie-rod ends from the spindle/steering knuckle, and, on 4WD cars, undo the front stabiliser bar. On early 4WD models, take out the bolts holding the power steering fluid cooler to the cross member, disconnect the hose for the fluid return line, let the fluid to drain and then detach the return hose and finally, the cooler. Remove the pressure and return hoses from the rack and pinion, caping the hoses and the rack and pinion ports for pressure and return to minimise on the entry of dirt and moisture into the power steering system. Loosen the steering column lower intermediate shaft pinch bolt connecting the rack and pinion input shaft, turn the key to the LOCK position and disconnect the lower intermediary from the rack and pinion then make sure not to twist the steering wheel while doing so in order not to tear the airbag sliding contact. Take out the nuts and mounting stud and nut, washer and stop also. On the 2WD models only, take off the rack and pinion assembly, and on the 4WD models only, take off the insulator bushings from the rack and pinion. Turn the rack and pinion control valve housing clockwise and rotate it forward simultaneously, turn the input shaft clockwise until it cannot be turned anymore, shift the rack and pinion as far to the right as you can, move the left tie-rod forward to get over the crossmember and then pull out the rack and pinion. For removal, reverse the installation steps including if any, replace any cracked, torn, or deteriorated insulators, tighten all the bolts to the recommended torque, use a special seal installation tool to install new seals on the power steering fluid pressure and return hose fittings, and get the alignment checked after the process.

Genuine Ford Rack And Pinion

Steering Rack And Pinion

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

624 Rack And Pinions found

View related parts
Ford Steering Gear
Part Number: HC3Z-3504-E
$781.94 MSRP: $1280.00
You Save: $498.06 (39%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering; Gear Assembly
- Replaces: 8C3Z-3504-B, 5C3Z-3504-BA, 7C3Z-3504-BA, HC3Z-3504-A, STG-462
Fits the following Ford Models:
- F-250 Super Duty | 2008-2016 | 10 Cyl 6.8L EFI, 8 Cyl 5.4L, 8 Cyl 6.2L OHC NA, 8 Cyl 6.4L Diesel Twin Turbo, 8 Cyl 6.7L Diesel T/C | 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Automatic Transmission (6R140), 6-Speed Manual Transmission M6HD-W, 6-Speed Manual Transmission Z/F S6-650, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
- F-350 Super Duty | 2008-2016 | 10 Cyl 6.8L EFI, 8 Cyl 5.4L, 8 Cyl 6.2L OHC NA, 8 Cyl 6.4L Diesel Twin Turbo, 8 Cyl 6.7L Diesel T/C | 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Automatic Transmission (6R140), 6-Speed Manual Transmission M6HD-W, 6-Speed Manual Transmission Z/F S6-650, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
- F-450 Super Duty | 2005-2017 | 10 Cyl 6.8L EFI, 8 Cyl 5.4L, 8 Cyl 6.0L Diesel OHV, 8 Cyl 6.2L OHC NA, 8 Cyl 6.4L Diesel Twin Turbo, 8 Cyl 6.7L Diesel T/C | 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Automatic Transmission (6R100), 6-Speed Automatic Transmission (6R140), 6-Speed Manual Transmission M6HD-W, 6-Speed Manual Transmission Z/F S6-650, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
- F-550 Super Duty | 2005-2017 | 10 Cyl 6.8L EFI, 8 Cyl 5.4L, 8 Cyl 6.0L Diesel OHV, 8 Cyl 6.2L OHC NA, 8 Cyl 6.4L Diesel Twin Turbo, 8 Cyl 6.7L Diesel T/C | 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Automatic Transmission (6R100), 6-Speed Automatic Transmission (6R140), 6-Speed Manual Transmission M6HD-W, 6-Speed Manual Transmission Z/F S6-650, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View More
View related parts
Ford Steering Gear
Part Number: HB5Z-3504-Z
$1433.66 MSRP: $2347.27
You Save: $913.61 (39%)
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering; Gear Assembly, Steering Gear
- Replaces: HB5Z-3504-A, HB5Z-3504-D, HB5Z-3504-Q, STE-372, HB5Z-3504-R, HB5Z-3504-M, HB5Z-3504-U, HB5Z-3504-J, STE-337, STE-363
Fits the following Ford Models:
- Explorer | 2017-2019 | 4 Cyl 2.3L TIVCT DI TC, 6 Cyl 3.5L Cyclone Petrol TIVCT, 6 Cyl 3.5L DOHC T/C | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F50, 6-Speed Automatic Transmission 6F55, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Steering Remanufactured Gear Assembly
Part Number: BB5Z-3504-AARM
$1133.38 MSRP: $1852.73
You Save: $719.35 (39%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering
- Replaced by: MU2Z-3V504-BRM
Fits the following Ford Models:
- Explorer | 2011-2012 | 4 Cyl 2.0L EcoBoost (240PS) , 6 Cyl 3.5L Cyclone Petrol TIVCT | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F50, 6-Speed Automatic Transmission 6F55, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Steering Gear
Part Number: DR3Z-3504-AE
$1494.38 MSRP: $2447.27
You Save: $952.89 (39%)
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering; Gear Assembly, Steering Gear
- Replaces: CR3Z-3504-AE, BR3Z-3504-KE, STE-76, STE-48
Fits the following Ford Models:
- Mustang | 2012-2014 | 6 Cyl 3.7L PFI NA, 8 Cyl 4.6L SOHC EFI, 8 Cyl 5.0L DOHC EFI Modular, 8 Cyl 5.0L MOD DOHC SEFI NA, 8 Cyl 5.4L DOHC EFI S/C ALUM, 8 Cyl 5.8L DOHC SC | 6-Speed Automatic Transmission (6R80), 6-Speed Manual Transmission (T56), 6-Speed Manual Transmission-MT82, Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Steering Gear
Part Number: HL3Z-3504-N
$1364.11 MSRP: $2232.73
You Save: $868.62 (39%)
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering; Gear Assembly, Steering Gear
- Replaces: HL3Z-3504-G
Fits the following Ford Models:
- F-150 | 2020, 2017 | 6 Cyl 2.7 L GAS, 6 Cyl 2.7L, 6 Cyl 3.0 L DIESEL, 6 Cyl 3.5 L GAS, 6 Cyl 3.5L Cyclone Petrol TIVCT, 6 Cyl 3.5L GTDI, 8 Cyl 5.0 L FLEX, 8 Cyl 5.0L MOD DOHC SEFI NA | 10-Speed Automatic Transmission (10R80), 6-Speed Automatic Transmission (6R80), Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Steering Gear
Part Number: ML3Z-3504-AA
$1213.97 MSRP: $1985.45
You Save: $771.48 (39%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Gear - Rack And Pinion Steering; Gear Assembly, Steering Gear
- Replaces: ML3Z-3504-H
Fits the following Ford Models:
- F-150 | 2021-2024 | 6 Cyl 2.7 L GAS, 6 Cyl 3.0 L DIESEL, 6 Cyl 3.3 L FLEX, 6 Cyl 3.5 L FULL HYBRID EV-GAS (FHEV), 6 Cyl 3.5 L GAS, 8 Cyl 5.0 L FLEX, 8 Cyl 5.2 L GAS
View related parts
Ford Steering Gear Assembly
Part Number: 7C3Z-3504-BRM
$443.49 MSRP: $720.00
You Save: $276.51 (39%)
ADD TO CART
Product Specifications
- Other Name: Gear Assy - Steering; Gear Assembly, Steering Gear
- Manufacturer Note: Remanufactured
- Replaces: 7C3Z-3504-B, DC3Z-3504-B, DC3Z-3504-E, STG-452, STG-263
Fits the following Ford Models:
- F-250 Super Duty | 2005-2008 | 8 Cyl 6.0L Diesel OHV, 8 Cyl 6.4L Diesel Twin Turbo | 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Manual Transmission M6HD-W, 6-Speed Manual Transmission Z/F S6-650, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
- F-350 Super Duty | 2005-2008 | 8 Cyl 6.0L Diesel OHV, 8 Cyl 6.4L Diesel Twin Turbo | 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Manual Transmission M6HD-W, 6-Speed Manual Transmission Z/F S6-650, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Steering Gear
Part Number: KB3Z-3504-A
$1186.37 MSRP: $1940.00
You Save: $753.63 (39%)
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering; Gear Assembly, Steering Gear
Fits the following Ford Models:
- Ranger | 2019-2020 | 4 Cyl 2.3 L GAS, 4 Cyl 2.3L TIVCT DI TC | 10-Speed Automatic Transmission (10R80), 2 Whl L/H Rear Drive-High Ride, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive
View related parts
Ford Steering Gear Assembly
Part Number: 3C3Z-3504-AA
$1108.09 MSRP: $1814.55
You Save: $706.46 (39%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering
- Replaces: F81Z-3504-AA
Fits the following Ford Models:
- F53 Stripped Chassis | 2011-2019, 2004-2009 | 10 Cyl 6.8L EFI, 10 Cyl 6.8L SOHC EFI NA | 5-Speed Automatic Transmission 5R110W NAAO, 6-Speed Automatic Transmission (6R140), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Steering Gear Assembly
Part Number: EB5Z-3504-A
$1729.52 MSRP: $2994.55
You Save: $1265.03 (43%)
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering
- Replaced by: E5BZ-3504-AM
Fits the following Ford Models:
- Explorer | 2014-2015 | 4 Cyl 2.0L EcoBoost (240PS) , 6 Cyl 3.5L Cyclone Petrol TIVCT | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F50, 6-Speed Automatic Transmission 6F55, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Steering Remanufactured Gear Assembly
Part Number: DB5Z-3504-MRM
$946.80 MSRP: $1545.45
You Save: $598.65 (39%)
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering
- Replaced by: MU2Z-3V504-GRM
Fits the following Ford Models:
- Explorer | 2013 | 4 Cyl 2.0L EcoBoost (240PS) , 6 Cyl 3.5L Cyclone Petrol TIVCT, 6 Cyl 3.5L DOHC T/C, 6 Cyl 3.7L DOHC | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F50, 6-Speed Automatic Transmission 6F55, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Steering Gear Assembly
Part Number: 8C3Z-3504-B
$781.94 MSRP: $1280.00
You Save: $498.06 (39%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering
- Manufacturer Note: Used With 7K Gear
- Replaced by: HC3Z-3504-E
Fits the following Ford Models:
- F-250 Super Duty | 2008-2016 | 10 Cyl 6.8L EFI, 8 Cyl 5.4L, 8 Cyl 6.2L OHC NA, 8 Cyl 6.4L Diesel Twin Turbo, 8 Cyl 6.7L Diesel T/C | 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Automatic Transmission (6R140), 6-Speed Manual Transmission M6HD-W, 6-Speed Manual Transmission Z/F S6-650, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
- F-350 Super Duty | 2008-2016 | 10 Cyl 6.8L EFI, 8 Cyl 5.4L, 8 Cyl 6.2L OHC NA, 8 Cyl 6.4L Diesel Twin Turbo, 8 Cyl 6.7L Diesel T/C | 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Automatic Transmission (6R140), 6-Speed Manual Transmission M6HD-W, 6-Speed Manual Transmission Z/F S6-650, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
- F-450 Super Duty | 2008-2016 | 10 Cyl 6.8L EFI, 8 Cyl 5.4L, 8 Cyl 6.2L OHC NA, 8 Cyl 6.4L Diesel Twin Turbo, 8 Cyl 6.7L Diesel T/C | 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Automatic Transmission (6R140), 6-Speed Manual Transmission M6HD-W, 6-Speed Manual Transmission Z/F S6-650, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
- F-550 Super Duty | 2008-2016 | 10 Cyl 6.8L EFI, 8 Cyl 5.4L, 8 Cyl 6.2L OHC NA, 8 Cyl 6.4L Diesel Twin Turbo, 8 Cyl 6.7L Diesel T/C | 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Automatic Transmission (6R140), 6-Speed Manual Transmission M6HD-W, 6-Speed Manual Transmission Z/F S6-650, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View More
View related parts
Ford Steering Gear
Part Number: 8W7Z-3504-ARM
$446.44 MSRP: $758.18
You Save: $311.74 (42%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering
- Replaces: 8W7Z-3504-A, STG-304
Fits the following Ford Models:
- Crown Victoria | 2008-2011 | 8 Cyl 4.6L Romeo SOHC EFI | 4-Speed Automatic Transmission 4R75E Livonia, Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Steering Remanufactured Gear Assembly
Part Number: BB5Z-3504-BARM
$1116.82 MSRP: $1825.45
You Save: $708.63 (39%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering
- Replaced by: MU2Z-3V504-CRM
Fits the following Ford Models:
- Explorer | 2011-2012 | 4 Cyl 2.0L EcoBoost (240PS) , 6 Cyl 3.5L Cyclone Petrol TIVCT | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F50, 6-Speed Automatic Transmission 6F55, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Steering Remanufactured Gear Assembly
Part Number: AE5Z-3504-EERM
$919.20 MSRP: $1500.00
You Save: $580.80 (39%)
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering
- Manufacturer Note: Remanufactured
- Replaced by: MU2Z-3V504-ARM
Fits the following Ford Models:
- Fusion | 2010-2012 | 4 Cyl 2.5L Duratec HE PFI, 4 Cyl 2.5L PFI Gas/Electric, 6 Cyl 3.0L OHC Duratec | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Steering Gear
Part Number: GU2Z-3504-A
$458.91 MSRP: $741.82
You Save: $282.91 (39%)
Ships in 1 Business Day
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering; Gear Assembly, Steering Gear
- Replaces: AC2Z-3504-A, STG-431
Fits the following Ford Models:
- E-150 | 2011-2014 | 10 Cyl 6.8L SOHC EFI NA, 8 Cyl 4.6L Romeo SOHC EFI, 8 Cyl 5.4L Modular SOHC, 8 Cyl 6.2L OHC NA | 4-Speed Automatic Transmission 4R70W (AODE), 4-Speed Automatic Transmission 4R75E Livonia, 4-Speed Automatic Transmission AODEW/4R70E W/TSS, 4-Speed Automatic Transmission AODEW/4R75E W/TSS, 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 6-Speed Automatic Transmission (6R140)
- E-250 | 2011-2014 | 10 Cyl 6.8L SOHC EFI NA, 8 Cyl 4.6L Romeo SOHC EFI, 8 Cyl 5.4L Modular SOHC, 8 Cyl 6.2L OHC NA | 4-Speed Automatic Transmission 4R70W (AODE), 4-Speed Automatic Transmission 4R75E Livonia, 4-Speed Automatic Transmission AODEW/4R70E W/TSS, 4-Speed Automatic Transmission AODEW/4R75E W/TSS, 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 6-Speed Automatic Transmission (6R140)
- E-350/E-350 Super Duty | 2021-2024, 2011-2019 | 10 Cyl 6.8L SOHC EFI NA, 8 Cyl 4.6L Romeo SOHC EFI, 8 Cyl 5.4L Modular SOHC, 8 Cyl 6.2L OHC NA, 8 Cyl 7.3 L GAS | 4-Speed Automatic Transmission 4R70W (AODE), 4-Speed Automatic Transmission 4R75E Livonia, 4-Speed Automatic Transmission AODEW/4R70E W/TSS, 4-Speed Automatic Transmission AODEW/4R75E W/TSS, 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 6-Speed Automatic Transmission (6R140)
- E-450 Super Duty | 2011-2019 | 10 Cyl 6.8L SOHC EFI NA, 8 Cyl 4.6L Romeo SOHC EFI, 8 Cyl 5.4L Modular SOHC, 8 Cyl 6.2L OHC NA | 4-Speed Automatic Transmission 4R70W (AODE), 4-Speed Automatic Transmission 4R75E Livonia, 4-Speed Automatic Transmission AODEW/4R70E W/TSS, 4-Speed Automatic Transmission AODEW/4R75E W/TSS, 5-Speed Automatic Transmission 5R110W - HI/Torque, 5-Speed Automatic Transmission 5R110W NAAO, 6-Speed Automatic Transmission (6R140)
View More
View related parts
Ford Steering Remanufactured Gear Assembly
Part Number: EB5Z-3504-BARM
$755.81 MSRP: $1230.91
You Save: $475.10 (39%)
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering
- Replaced by: MU2Z-3V504-HRM
Fits the following Ford Models:
- Explorer | 2013-2015 | 4 Cyl 2.0L EcoBoost (240PS) , 4 Cyl 2.3L TIVCT DI TC, 6 Cyl 3.5L Cyclone Petrol TIVCT, 6 Cyl 3.5L DOHC T/C, 6 Cyl 3.7L DOHC | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F50, 6-Speed Automatic Transmission 6F55, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Steering Gear Assembly
Part Number: DB5Z-3504-LE
$1707.46 MSRP: $2798.18
You Save: $1090.72 (39%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering
- Replaced by: EB5Z-3504-BL
Fits the following Ford Models:
- Explorer | 2014 | 6 Cyl 3.5L Cyclone Petrol TIVCT, 6 Cyl 3.5L DOHC T/C, 6 Cyl 3.7L DOHC | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F50, 6-Speed Automatic Transmission 6F55, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Steering Gear Assembly
Part Number: DB5Z-3504-KE
$1729.52 MSRP: $2994.55
You Save: $1265.03 (43%)
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering
- Replaced by: E5BZ-3504-AM
Fits the following Ford Models:
- Explorer | 2014 | 4 Cyl 2.0L EcoBoost (240PS) , 6 Cyl 3.5L Cyclone Petrol TIVCT | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F50, 6-Speed Automatic Transmission 6F55, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Steering Gear Assembly
Part Number: BC3Z-3504-B
$549.00 MSRP: $896.36
You Save: $347.36 (39%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Gear Assembly - Steering
- Manufacturer Note: Used With 6K Gear
- Replaced by: GC3Z-3504-E
Fits the following Ford Models:
- F-250 Super Duty | 2011-2016 | 8 Cyl 6.7L Diesel T/C | 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Automatic Transmission (6R140), Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
- F-350 Super Duty | 2011-2016 | 8 Cyl 6.7L Diesel T/C | 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Automatic Transmission (6R140), Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
- F-450 Super Duty | 2011-2016 | 8 Cyl 6.7L Diesel T/C | 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Automatic Transmission (6R140), Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
- F-550 Super Duty | 2011-2016 | 8 Cyl 6.7L Diesel T/C | 5-Speed Automatic Transmission 5R110W NAAO, 5-Speed Manual Transmission-Tremec TR4050, 6-Speed Automatic Transmission (6R140), Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View More

| Page 1 of 32 |Next >

1-20 of 624 Results

Ford Rack And Pinion Parts Questions & Experts Answers

Steering Gear Assembly
8L5Z-3504-B
Q:
How to remove and install the Rack and Pinion steering gear on Ford Ranger?
Posted by Slate N.
A:
To pull out the rack and pinion assembly, the front wheels turned straight ahead and the vehicle supported adequately by jackstands. Connect the cable or jumper wire to the negative terminal of the battery, then return the steering wheel to its straight ahead position, without locking the steering column unless for 2011 models the column should be locked. The hose connections to the power steering fluid cooler for V6 2WD are to be removed, fluid drained into a suitable receptacle and the cooler removed. For 4WD models depending on variants, there are screws and retaining pins; therefore, at the side, the air deflector screws should be unscrewed and the air deflector clips must be unlocked. Detach the tie-rod ends from the spindle/steering knuckle, and, on 4WD cars, undo the front stabiliser bar. On early 4WD models, take out the bolts holding the power steering fluid cooler to the cross member, disconnect the hose for the fluid return line, let the fluid to drain and then detach the return hose and finally, the cooler. Remove the pressure and return hoses from the rack and pinion, caping the hoses and the rack and pinion ports for pressure and return to minimise on the entry of dirt and moisture into the power steering system. Loosen the steering column lower intermediate shaft pinch bolt connecting the rack and pinion input shaft, turn the key to the LOCK position and disconnect the lower intermediary from the rack and pinion then make sure not to twist the steering wheel while doing so in order not to tear the airbag sliding contact. Take out the nuts and mounting stud and nut, washer and stop also. On the 2WD models only, take off the rack and pinion assembly, and on the 4WD models only, take off the insulator bushings from the rack and pinion. Turn the rack and pinion control valve housing clockwise and rotate it forward simultaneously, turn the input shaft clockwise until it cannot be turned anymore, shift the rack and pinion as far to the right as you can, move the left tie-rod forward to get over the crossmember and then pull out the rack and pinion. For removal, reverse the installation steps including if any, replace any cracked, torn, or deteriorated insulators, tighten all the bolts to the recommended torque, use a special seal installation tool to install new seals on the power steering fluid pressure and return hose fittings, and get the alignment checked after the process.
Answered by Ford Parts Specialist Ley / Jul 01, 2023

Related Ford Parts

Browse by Model

Bronco Rack And Pinion Bronco Sport Rack And Pinion C-Max Rack And Pinion Contour Rack And Pinion Crown Victoria Rack And Pinion E-150 Rack And Pinion E-250 Rack And Pinion E-350/E-350 Super Duty Rack And Pinion E-450 Super Duty Rack And Pinion E-Transit Rack And Pinion EcoSport Rack And Pinion Edge Rack And Pinion Escape Rack And Pinion Escort Rack And Pinion Expedition Rack And Pinion Explorer Rack And Pinion Explorer Sport Rack And Pinion Explorer Sport Trac Rack And Pinion F-150 Lightning Rack And Pinion F-150 Rack And Pinion F-250 Super Duty Rack And Pinion F-350 Super Duty Rack And Pinion F-450 Super Duty Rack And Pinion F-550 Super Duty Rack And Pinion F53 Stripped Chassis Rack And Pinion Fairmont Rack And Pinion Fiesta Rack And Pinion Five Hundred Rack And Pinion Flex Rack And Pinion Focus Rack And Pinion Freestar Rack And Pinion Freestyle Rack And Pinion Fusion Rack And Pinion Granada Rack And Pinion GT Rack And Pinion LTD Rack And Pinion Maverick Rack And Pinion Mustang Mach-E Rack And Pinion Mustang Rack And Pinion Police Interceptor Sedan Rack And Pinion Police Interceptor Utility Rack And Pinion Police Responder Hybrid Rack And Pinion Ranger Rack And Pinion SSV Plug-In Hybrid Rack And Pinion Taurus Rack And Pinion Taurus X Rack And Pinion Tempo Rack And Pinion Thunderbird Rack And Pinion Transit Connect Rack And Pinion Transit Rack And Pinion