How to remove, inspect, and install the flywheel and driveplate on Ford Escape?

In order to do this, some of the related components such as oil seals will have to be (checked and) replaced or (checked and) if necessary. In manual transaxle vehicles demount the clutch and check and renewal of its components as required. It would be prudent to scratch lines on the flywheel/drive plate and the crankshaft so that when assembling the car the next time it would be easier to align because the bolt holes are slightly offset. To immobilise the flywheel/drive plate, have assistance for turning the screw on the lower end with a screwdriver, or use a piece of angle-iron pressed against the transaxle mounting bolt. Unwind also and slide out each bolt because they are often replaced with new ones whenever using them again since they work under high stress. It is important not to drop the flywheel/drive plate while taking it off, so needs to be done very carefully. For inspection, examine driveplates for any signs of crack as well as elongation of bolt holes and examine ring gear teeth for any signs of damages. Remove grease or oil from the flywheel and examine for cracks and warpage, and check the mating surfaces for leaks it is recommended that the oil seal be replaced. As it is necessary to clean the inboard face of the flywheel and the tip of the sensor, you should do it when the flywheel is off. When installing, make sure the engine/transaxle adapter plate is installed, rotate the flywheel/drive plate and align with the marks made when removing, use new bolts, torque by hand. Secure the flywheel/drive plate as described above for removal, then install new bolts and tighten, in a diagonal pattern, to the specified torque. The balance of the installation works in the sequence if the removal process.

Genuine Ford Escape Flywheel

Clutch Flywheel

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

14 Flywheels found

View related parts
Ford Escape Flywheel Assembly
Part Number: CV6Z-6375-C
$84.14 MSRP: $123.02
You Save: $38.88 (32%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Flywheel Assy; Drive Plate
- Replaced by: CV6Z-6375-E
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2013-2019 Ford Escape | 4 Cyl 1.5L EcoBoost 16V (180PS), 4 Cyl 1.6L EcoBoost SCTi -Sigma | 6-Speed Automatic Transmission 6F Mid-Range, Four-Wheel Drive, Four-Wheel Drive (Part Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Front-Wheel Drive (Right Hand Drive), Left Hand Drive, Two-Wheel Drive (Left Hand Drive)
View related parts
Ford Escape Flywheel Assembly
Part Number: 1S7Z-6375-C
$75.81 MSRP: $110.83
You Save: $35.02 (32%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Flywheel Assy; Drive Plate
- Replaced by: 1S7Z-6375-E
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2014-2019 Ford Escape | 4 Cyl 2.0L, 4 Cyl 2.0L EcoBoost (240PS) , 4 Cyl 2.5L Duratec (110kW/150PS), 4 Cyl 2.5L Duratec FFV (125kW/170PS) | 6-Speed Automatic Transmission 6F Mid-Range, Four-Wheel Drive, Four-Wheel Drive (Part Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Front-Wheel Drive (Right Hand Drive), Left Hand Drive, Two-Wheel Drive (Left Hand Drive)
View related parts
Ford Escape Flywheel And Ring Gear Assembly
Part Number: 5M6Z-6375-AA
$96.59 MSRP: $134.18
You Save: $37.59 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Flywheel And Ring Gear Assy; Drive Plate, Flywheel
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2005-2012 Ford Escape | 4 Cyl 2.3L Hybrid Gas/Electric DOHC, 4 Cyl 2.5L PFI Gas/Electric | 4AT CD4E, 5-Speed Manual Transmission - AK, 6-Speed Automatic Transmission 6F Mid-Range, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Escape Flywheel Assembly
Part Number: 5L8Z-6477-AA
$479.80 MSRP: $707.67
You Save: $227.87 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Flywheel Assy; Flywheel
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2005-2012 Ford Escape | 4 Cyl 2.3L, 4 Cyl 2.5L Duratec (110kW/150PS) | 5-Speed Manual Transmission, 5-Speed Manual Transmission - AK, Four-Wheel Drive (Full Time) (Left Hand Drive), Four-Wheel Drive (Right Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive, Two-Wheel Drive (Left Hand Drive), Two-Wheel Drive (Right Hand Drive)
View related parts
Ford Escape Flywheel Assembly
Part Number: 1S7Z-6375-B
$75.81 MSRP: $110.83
You Save: $35.02 (32%)
Ships in 1 Business Day
ADD TO CART
Product Specifications
- Other Name: Flywheel Assy
- Replaced by: 1S7Z-6375-E
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2013 Ford Escape | 4 Cyl 2.0L, 4 Cyl 2.5L Duratec (110kW/150PS), 4 Cyl 2.5L Duratec FFV (125kW/170PS) | 6-Speed Automatic Transmission 6F Mid-Range, Four-Wheel Drive, Four-Wheel Drive (Part Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Front-Wheel Drive (Right Hand Drive), Left Hand Drive, Two-Wheel Drive (Left Hand Drive)
View related parts
Ford Escape Flywheel Assembly
Part Number: 1L8Z-6375-AA
$75.81 MSRP: $110.83
You Save: $35.02 (32%)
Ships in 1 Business Day
ADD TO CART
Product Specifications
- Other Name: Flywheel Assy
- Manufacturer Note: A/T
- Replaced by: 1S7Z-6375-E
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2005-2012 Ford Escape | 4 Cyl 2.3L, 4 Cyl 2.5L Duratec (110kW/150PS) | 4AT CD4E, 6-Speed Automatic Transmission 6F Mid-Range, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Four-Wheel Drive (Right Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive, Two-Wheel Drive (Left Hand Drive), Two-Wheel Drive (Right Hand Drive)
View related parts
Ford Escape Flywheel And Ring Gear Assembly
Part Number: DG9Z-6375-B
$218.77 MSRP: $322.67
You Save: $103.90 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Flywheel And Ring Gear Assy; Drive Plate, Flywheel
- Replaced by: DG9Z-6375-C
- Replaces: DG9Z-6375-A
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2020-2025 Ford Escape | 3 Cyl 1.5 L GAS, 4 Cyl 2.0 L GAS, 4 Cyl 2.5 L FULL HYBRID EV-GAS (FHEV), 4 Cyl 2.5 L PLUG-IN HYBRID EV-GAS (PHEV)
View related parts
Ford Escape FLYWHEEL ASY
Part Number: 1S7Z-6375-E
$75.81 MSRP: $110.83
You Save: $35.02 (32%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Drive Plate
- Replaces: 1S7Z-6375-D, 1L8Z-6375-AA, 1S7Z-6375-B, 1S7Z-6375-C
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2005-2025 Ford Escape | 3 Cyl 1.5 L GAS, 4 Cyl 2.0 L GAS, 4 Cyl 2.0L, 4 Cyl 2.0L EcoBoost (240PS), 4 Cyl 2.3L, 4 Cyl 2.5 L FULL HYBRID EV-GAS (FHEV), 4 Cyl 2.5 L PLUG-IN HYBRID EV-GAS (PHEV), 4 Cyl 2.5L Duratec (110kW/150PS), 4 Cyl 2.5L Duratec FFV (125kW/170PS) | 4AT CD4E, 6-Speed Automatic Transmission 6F Mid-Range, CVT Auto Trans Powersplit Elec, Four-Wheel Drive, Four-Wheel Drive (Full Time) (Left Hand Drive), Four-Wheel Drive (Part Time) (Left Hand Drive), Four-Wheel Drive (Right Hand Drive), Front-Wheel Drive (Left Hand Drive), Front-Wheel Drive (Right Hand Drive), Left Hand Drive, Two-Wheel Drive (Left Hand Drive), Two-Wheel Drive (Right Hand Drive)
View related parts
Ford Escape Flywheel Assembly
Part Number: YL8Z-6375-AA
$44.31 MSRP: $63.67
You Save: $19.36 (31%)
Product Specifications
- Other Name: Flywheel Assy; Drive Plate
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2001-2008 Ford Escape | 6 Cyl 3.0L DOHC EFI Modular | 4AT CD4E, 5-Speed Manual Transmission, 5-Speed Manual Transmission - AK, 6-Speed Automatic Transmission 6F Mid-Range, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Four-Wheel Drive (Right Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive, Two-Wheel Drive (Left Hand Drive), Two-Wheel Drive (Right Hand Drive)
View related parts
Ford Escape Flywheel Assembly
Part Number: F8RZ-6375-BA
Product Specifications
- Other Name: Flywheel Assy; Drive Plate, Flywheel
- Replaces: F5RZ-6375-B
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2001-2004 Ford Escape | 4 Cyl 2.0L Zetec EFI | 4AT CD4E, Four-Wheel Drive (Full Time) (Left Hand Drive), Four-Wheel Drive (Right Hand Drive), Left Hand Drive, Two-Wheel Drive (Left Hand Drive), Two-Wheel Drive (Right Hand Drive)
View related parts
Ford Escape Flywheel Assembly
Part Number: 9L8Z-6375-A
Product Specifications
- Other Name: Flywheel Assy; Drive Plate, Flywheel
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2009-2012 Ford Escape | 6 Cyl 3.0L OHC Duratec | 4AT CD4E, 5-Speed Manual Transmission - AK, 6-Speed Automatic Transmission 6F Mid-Range, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Escape Flywheel Assembly
Part Number: GN1Z-6375-C
$55.40 MSRP: $81.00
You Save: $25.60 (32%)
Product Specifications
- Other Name: FLYWHEEL ASY; Drive Plate
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2020-2025 Ford Escape | 3 Cyl 1.5 L GAS, 4 Cyl 2.0 L GAS, 4 Cyl 2.5 L FULL HYBRID EV-GAS (FHEV), 4 Cyl 2.5 L PLUG-IN HYBRID EV-GAS (PHEV)
View related parts
Ford Escape Flywheel Assembly
Part Number: YL8Z-6375-BA
Product Specifications
- Other Name: Flywheel Assy
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2001-2003 Ford Escape | 4 Cyl 2.0L Zetec EFI | 5-Speed Manual Transmission, Four-Wheel Drive (Full Time) (Left Hand Drive), Four-Wheel Drive (Right Hand Drive), Left Hand Drive, Two-Wheel Drive (Left Hand Drive), Two-Wheel Drive (Right Hand Drive)
View related parts
Ford Escape Flywheel And Ring Gear Assy
Part Number: F8CZ-6375-BA
Product Specifications
- Other Name: Flywheel
- Manufacturer Note: MTX
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2003-2004 Ford Escape | 4 Cyl 2.0L Zetec EFI | 5-Speed Manual Transmission, Four-Wheel Drive (Full Time) (Left Hand Drive), Four-Wheel Drive (Right Hand Drive), Left Hand Drive, Two-Wheel Drive (Left Hand Drive), Two-Wheel Drive (Right Hand Drive)

Ford Escape Flywheel

The Flywheel in this Ford Escape product is a large heavy rotating energy bank that smooths engine pulses and kick starts each drive. The Flywheel is fastened to the crankshaft of the engine to store momentum. It smooths out the surges in the engine's combustion and makes the engine run more evenly. A ring gear meshes with the starter to turn the engine on. Its flat face grips the disc of the clutch to transmit power to the gearbox. Throughout the lifetime of a Ford Escape, two types of Flywheel have been applied, a basic solid disc and the more complex dual-mass design. The solid Flywheel is just one piece of steel, sometimes slightly machined if its surface gets hot spots or score marks, whereas the dual-mass contains two main parts or plates each cushioned by springs which absorb vibration and improve the feel of the shift. The dual-mass usually has to be replaced not resurfaced if the damper or bearing area wears out though. The highly common reason that Ford Escape owners install a new Flywheel is wear from repeated clutch engagements or chipped ring gear teeth which keeps your Ford Escape drivetrain smooth and quiet.

We provide a wide range of Ford Escape Flywheel at the optimal prices. If you need Ford Escape Flywheel, you can shop with confidence on our website. All our OEM parts come with a manufacturer's warranty and are delivered to your doorstep with a fast delivery service.

Ford Escape Flywheel Parts Questions & Experts Answers

Flywheel Assembly
YL8Z-6375-AA
Q: How to remove, inspect, and install the flywheel and driveplate on Ford Escape?
A:
In order to do this, some of the related components such as oil seals will have to be (checked and) replaced or (checked and) if necessary. In manual transaxle vehicles demount the clutch and check and renewal of its components as required. It would be prudent to scratch lines on the flywheel/drive plate and the crankshaft so that when assembling the car the next time it would be easier to align because the bolt holes are slightly offset. To immobilise the flywheel/drive plate, have assistance for turning the screw on the lower end with a screwdriver, or use a piece of angle-iron pressed against the transaxle mounting bolt. Unwind also and slide out each bolt because they are often replaced with new ones whenever using them again since they work under high stress. It is important not to drop the flywheel/drive plate while taking it off, so needs to be done very carefully. For inspection, examine driveplates for any signs of crack as well as elongation of bolt holes and examine ring gear teeth for any signs of damages. Remove grease or oil from the flywheel and examine for cracks and warpage, and check the mating surfaces for leaks it is recommended that the oil seal be replaced. As it is necessary to clean the inboard face of the flywheel and the tip of the sensor, you should do it when the flywheel is off. When installing, make sure the engine/transaxle adapter plate is installed, rotate the flywheel/drive plate and align with the marks made when removing, use new bolts, torque by hand. Secure the flywheel/drive plate as described above for removal, then install new bolts and tighten, in a diagonal pattern, to the specified torque. The balance of the installation works in the sequence if the removal process.

Genuine Ford Escape Flywheel

14 Flywheels found

Ford Escape Flywheel Assembly

Ford Escape Flywheel Assembly

Ford Escape Flywheel And Ring Gear Assembly

Ford Escape Flywheel Assembly

Ford Escape Flywheel Assembly

Ford Escape Flywheel Assembly

Ford Escape Flywheel And Ring Gear Assembly

Ford Escape FLYWHEEL ASY

Ford Escape Flywheel Assembly

Ford Escape Flywheel Assembly

Ford Escape Flywheel Assembly

Ford Escape Flywheel Assembly

Ford Escape Flywheel Assembly

Ford Escape Flywheel And Ring Gear Assy

Ford Escape Flywheel

Ford Escape Flywheel Parts Questions & Experts Answers

Related Ford Escape Parts

Browse by Year