How to remove and install Windshield Washer Pump and Windshield Washer Reservoir on Ford Explorer?

To service the front washer, start by unlocking the electrical connector tabs with a small screwdriver and unplugging the Windshield Washer Pump electrical connector. For models from 2001 onward, remove the air cleaner. Next, take out the two screws that secure the Windshield Washer Reservoir and pump motor assembly to the fender well; note that on later models, the Windshield Washer Reservoir and coolant recovery tank are combined. Lift the Windshield Washer Reservoir and disconnect the small hose at its base, covering the end to prevent fluid spillage, then remove the reservoir. Drain the washer fluid into a clean container for potential reuse. Use a small screwdriver to carefully pry out the retaining ring that holds the pump motor in place, then grasp the wall surrounding the electrical terminal with pliers and pull the motor, seal, and impeller assembly out. If the impeller and seal separate from the motor, they can be reassembled. Clean the reservoir with water and inspect it for any debris. Before installing an old motor into a new reservoir, check the pump chamber and clean it if needed. Lubricate the outer surface of the seal with powdered graphite for easier installation, align the small projection on the motor end cap with the slot in the reservoir, and push it in until the seal is seated. Secure the retaining ring against the motor and plate using a 1-inch 12-point socket, then connect the hose to the reservoir fitting. Install the reservoir in the engine compartment, secure it with screws, and reconnect the electrical connector. Ensure the pump is not operated without fluid in the reservoir to avoid damage, then fill the reservoir, operate the pump, and check for leaks. For the rear washer, applicable only to models from 1991 to 1996, remove the quarter trim panel from the driver's side of the cargo area, disconnect the filler hose and electrical connector from the pump motor, pour the fluid into a container, and disconnect the discharge hose before removing the reservoir. Carefully pry the pump out of the reservoir, remove the seal and filter, and during installation, lubricate the inside of the seal with soapy water before pushing the pump in securely. Fill the reservoir slowly to avoid trapping air in the system, and do not operate the washers without fluid.

Genuine Ford Explorer Windshield Washer Reservoir

Washer Reservoir

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

14 Windshield Washer Reservoirs found

View related parts
Ford Explorer Windshield Reservoir
Part Number: 2L2Z-17618-AA
$53.89 MSRP: $90.73
You Save: $36.84 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Reservoir - Windshield Washer
- Replaced by: 8L5Z-17618-A
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1998-2001 Ford Explorer | 6 Cyl 4.0L, 8 Cyl 5.0L | 4AT 4R70W, 5AT 5R55E, 5MT
View related parts
Ford Explorer Windshield Washer Reservoir
Part Number: FB5Z-17618-B
$125.78 MSRP: $212.73
You Save: $86.95 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Reservoir - Windshield Washer
- Replaced by: FB5Z-17618-C
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2016-2018 Ford Explorer | 4 Cyl 2.3L TIVCT DI TC, 6 Cyl 3.5L Cyclone Petrol TIVCT, 6 Cyl 3.5L DOHC T/C, 6 Cyl 3.7L DOHC | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F50, 6-Speed Automatic Transmission 6F55, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Explorer Reservoir Assembly
Part Number: BB5Z-17618-A
$80.26 MSRP: $128.00
You Save: $47.74 (38%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Reservoir - Windshield Washer; Reservoir Assembly
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2011-2015 Ford Explorer | 4 Cyl 2.0L EcoBoost (240PS) , 4 Cyl 2.3L TIVCT DI TC, 6 Cyl 3.5L Cyclone Petrol TIVCT, 6 Cyl 3.5L DOHC T/C, 6 Cyl 3.7L DOHC | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F50, 6-Speed Automatic Transmission 6F55, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Explorer Washer Reservoir
Part Number: 5L2Z-17618-CA
$135.38 MSRP: $188.07
You Save: $52.69 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Reservoir - Windshield Washer; Washer Reservoir
- Manufacturer Note: Less Sensor
- Replaces: 3L2Z-17618-AA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2003-2005 Ford Explorer | 6 Cyl 4.0L SOHC EFI, 8 Cyl 4.6L Romeo SOHC EFI | 5-Speed Automatic Transmission 5R55S, 5-Speed Automatic Transmission 5R55W, 5-Speed Manual Transmission (M5R4), 6-Speed Automatic Transmission (6R80), 6-Speed Automatic Transmission 6R60, Four-Wheel Drive (Full Time) (Left Hand Drive), Four-Wheel Drive (Part Time) (Left Hand Drive), Four-Wheel Drive (Part Time) (Right Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Explorer Reservoir Assembly
Part Number: FB5Z-17618-C
$125.78 MSRP: $212.73
You Save: $86.95 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Reservoir - Windshield Washer; Reservoir, Reservoir Assembly
- Replaces: FB5Z-17618-B
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2016-2019 Ford Explorer | 4 Cyl 2.3L TIVCT DI TC, 6 Cyl 3.5L Cyclone Petrol TIVCT, 6 Cyl 3.5L DOHC T/C, 6 Cyl 3.7L DOHC | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F50, 6-Speed Automatic Transmission 6F55, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Explorer Reservoir Assembly
Part Number: LB5Z-17618-G
$196.27 MSRP: $316.36
You Save: $120.09 (38%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Reservoir - Windshield Washer; Reservoir, Reservoir Assembly
- Replaces: LB5Z-17618-F, LB5Z-17618-E, LB5Z-17618-A
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2020-2024 Ford Explorer | 4 Cyl 2.3 L GAS, 6 Cyl 3.0 L GAS, 6 Cyl 3.3 L FLEX, 6 Cyl 3.3 L FULL HYBRID EV-GAS (FHEV)
View related parts
Ford Explorer Reservoir Assembly
Part Number: RB5Z-17618-A
$62.24 MSRP: $99.27
You Save: $37.03 (38%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Reservoir - Windshield Washer; Reservoir, Reservoir Assembly
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2024-2025 Ford Explorer | 4 Cyl 2.3 L GAS, 6 Cyl 3.0 L GAS
View related parts
Ford Explorer Water Reservoir
Part Number: F57Z-17618-BA
Product Specifications
- Other Name: Reservoir - Water
- Replaced by: F77Z-17618-A
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1995-1997 Ford Explorer | 6 Cyl 4.0L, 8 Cyl 5.0L | 4AT 4R44E, 4AT 4R55E, 4AT 4R70W, 4AT A4LD, 4AT AODE-E, 4AT AODE-W, 5AT 5R55E, 5MT
View related parts
Ford Explorer Water Reservoir
Part Number: E7TZ-17618-B
Product Specifications
- Other Name: Reservoir - Water
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1991-1994 Ford Explorer | 6 Cyl 4.0L | 4AT A4LD, 5MT
View related parts
Ford Explorer Water Reservoir
Part Number: F57Z-17618-AA
Product Specifications
- Other Name: Reservoir - Water; Recovery Tank, Reservoir, Washer Reservoir
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1995-1997 Ford Explorer | 6 Cyl 4.0L, 8 Cyl 5.0L | 4AT 4R44E, 4AT 4R55E, 4AT 4R70W, 4AT A4LD, 4AT AODE-E, 4AT AODE-W, 5AT 5R55E, 5MT
View related parts
Ford Explorer Washer Reservoir
Part Number: 3L2Z-17618-BA
Product Specifications
- Other Name: Reservoir - Windshield Washer; Washer Reservoir
- Manufacturer Note: For Message Center
- Replaces: 1L2Z-17618-BA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2002-2010 Ford Explorer | 6 Cyl 4.0L SOHC EFI, 8 Cyl 4.6L, 8 Cyl 4.6L Romeo SOHC EFI | 5-Speed Automatic Transmission 5R55S, 5-Speed Automatic Transmission 5R55W, 5-Speed Manual Transmission (M5R4), 6-Speed Automatic Transmission (6R80), 6-Speed Automatic Transmission 6R60, Four-Wheel Drive (Full Time) (Left Hand Drive), Four-Wheel Drive (Part Time) (Left Hand Drive), Four-Wheel Drive (Part Time) (Right Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Explorer Windshield Washer Reservoir
Part Number: 1L2Z-17618-BA
Product Specifications
- Other Name: Reservoir - Windshield Washer
- Replaced by: 3L2Z-17618-BA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2002-2003 Ford Explorer | 6 Cyl 4.0L SOHC EFI, 8 Cyl 4.6L Romeo SOHC EFI | 5-Speed Automatic Transmission 5R55S, 5-Speed Automatic Transmission 5R55W, 5-Speed Manual Transmission (M5R4), 6-Speed Automatic Transmission (6R80), 6-Speed Automatic Transmission 6R60, Four-Wheel Drive (Full Time) (Left Hand Drive), Four-Wheel Drive (Part Time) (Left Hand Drive), Four-Wheel Drive (Part Time) (Right Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Explorer Reservoir Windshield Washer
Part Number: 3L2Z-17618-AA
Product Specifications
- Other Name: Reservoir - Windshield Washer
- Replaced by: 5L2Z-17618-CA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2003 Ford Explorer | 6 Cyl 4.0L SOHC EFI, 8 Cyl 4.6L Romeo SOHC EFI | 5-Speed Automatic Transmission 5R55S, 5-Speed Automatic Transmission 5R55W, 5-Speed Manual Transmission (M5R4), 6-Speed Automatic Transmission (6R80), 6-Speed Automatic Transmission 6R60, Four-Wheel Drive (Full Time) (Left Hand Drive), Four-Wheel Drive (Part Time) (Left Hand Drive), Four-Wheel Drive (Part Time) (Right Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Explorer Reservoir Water
Part Number: F1TZ17618A
Product Specifications
- Other Name: Reservoir - Water; Reservoir
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1991-1997 Ford Explorer | 6 Cyl 4.0L, 8 Cyl 5.0L | 4AT 4R44E, 4AT 4R55E, 4AT 4R70W, 4AT A4LD, 4AT AODE-E, 4AT AODE-W, 5AT 5R55E, 5MT

Ford Explorer Windshield Washer Reservoir

We provide a wide range of Ford Explorer Windshield Washer Reservoir at the optimal prices. If you need Ford Explorer Windshield Washer Reservoir, you can shop with confidence on our website. All our OEM parts come with a manufacturer's warranty and are delivered to your doorstep with a fast delivery service.

Ford Explorer Windshield Washer Reservoir Parts Questions & Experts Answers

Windshield Reservoir
2L2Z-17618-AA
Q:
How to remove and install Windshield Washer Pump and Windshield Washer Reservoir on Ford Explorer?
Posted by Jonny M.
A:
To service the front washer, start by unlocking the electrical connector tabs with a small screwdriver and unplugging the Windshield Washer Pump electrical connector. For models from 2001 onward, remove the air cleaner. Next, take out the two screws that secure the Windshield Washer Reservoir and pump motor assembly to the fender well; note that on later models, the Windshield Washer Reservoir and coolant recovery tank are combined. Lift the Windshield Washer Reservoir and disconnect the small hose at its base, covering the end to prevent fluid spillage, then remove the reservoir. Drain the washer fluid into a clean container for potential reuse. Use a small screwdriver to carefully pry out the retaining ring that holds the pump motor in place, then grasp the wall surrounding the electrical terminal with pliers and pull the motor, seal, and impeller assembly out. If the impeller and seal separate from the motor, they can be reassembled. Clean the reservoir with water and inspect it for any debris. Before installing an old motor into a new reservoir, check the pump chamber and clean it if needed. Lubricate the outer surface of the seal with powdered graphite for easier installation, align the small projection on the motor end cap with the slot in the reservoir, and push it in until the seal is seated. Secure the retaining ring against the motor and plate using a 1-inch 12-point socket, then connect the hose to the reservoir fitting. Install the reservoir in the engine compartment, secure it with screws, and reconnect the electrical connector. Ensure the pump is not operated without fluid in the reservoir to avoid damage, then fill the reservoir, operate the pump, and check for leaks. For the rear washer, applicable only to models from 1991 to 1996, remove the quarter trim panel from the driver's side of the cargo area, disconnect the filler hose and electrical connector from the pump motor, pour the fluid into a container, and disconnect the discharge hose before removing the reservoir. Carefully pry the pump out of the reservoir, remove the seal and filter, and during installation, lubricate the inside of the seal with soapy water before pushing the pump in securely. Fill the reservoir slowly to avoid trapping air in the system, and do not operate the washers without fluid.
Answered by Ford Parts Specialist Ley / Aug 19, 2022

Related Ford Explorer Parts

Browse by Year